Product ID:403748, QUAKER STATE HD MOTOR OIL (40)
MSDS Date:07/01/1990
FSC:9150
NIIN:00N031319
MSDS Number: BNSDD

QUAKER STATE CORP

OIL CITY, PA 16301
US

Emergency Phone: 814-676-7676

Info Phone: 814-676-7676

Cage: DO899

QUAKER STATE OIL REFINING CORPORATION

OIL CITY, PA 16301 US

Telephone: 814-676-7676

Cage: DO899

THORO W/SOAP & WATER AFTER CONTACT,

RTECS: 9999999ZZ

OF CONTAMINATED CLOTHING IS ESSENTIAL TO REDUCE

RTECS: 9999999ZZ

MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')

CAS: 8012-95-1

RTECS: PY8030000

Fraction By Weight: >90%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3;10 STEL

ADDITIVE PACKAGE

Fraction By Weight: <10%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST: NOT EXPECTED TO BE
ACUTELY TOXIC BY INGESTION. MAY CAUSE NAUSEA AND DIARRHEA. INHAL:
NOT EXPECTED TO BE TOXIC BY INHALATION. HOWEVER, BRTHG MINERAL OIL
MISTS @ LEVELS ABOVE TLV MAY CAUS E RESP IRRIT & POSSIBLE
DISCOMFORT. THECREATION OF AN OIL MIST IS UNLIKELY WHEN USED AS A
MOTOR OIL. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVENT
Effects of Overexposure:HLTH HAZ:SKIN:MATL EXPECTED TO CAUSE NO MORE
THAN MINOR SKIN IRRIT FOLLOWING PROLONGED &/OR REPEATED CONTACT.
EYE: MAY CAUSE MINOR EYE IRRITATION. CHRONIC: NONE KNOWN.NOTE TO
MD: USED MOTOR OILS HAVE BEEN SHOWN TO CAUSE SKIN CANCER IN
MICEFOLLOWING RPTD APPLICATION & CONTINUOUS EXPOS.
BRIEF/INTERMITTENT (SUPP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST:DO NOT INDUCE VOMIT & CNTCT MD. SKIN: WASH THORO
W/SOAP & H2O. LAUNDER SOILED CLTHG. INHAL:ALTHOUGH INHAL OF MATL IS
UNLIKELY, IF RESP DISCOMFORT/IRRIT OCCURS DUE TO INHAL OF OIL MIST,
MOVE PER SON TO FRESH AIR. CNTCT MD IF DISCOMFORT/IRRIT CONTINUES.
EYES: FLUSH W/H2O FOR @ LST 15 MIN. IF IRRIT CONTINUES, CNTCT MD.

Flash Point Method:COC
Flash Point:400F,204C
Extinguishing Media:CO2, DRY CHEM, FOAM, H2O FOG. H2O MAY BE INEFTIVE
IN FIGHTING AN OIL FIRE UNLESS USED BY EXPERIENCED FIRE FIGTERS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST WHEN EXPOSED TO FIRE
CONDITIONS.

Spill Release Procedures:CLEAN UP SPILL AS SOON AS POSSIBLE. ABSORB
LARGE SPILLS WITH COMMERCIALLY AVAILABLE ABSORBENT MATERIALS, SUCH
AS ABSORBENT CLAY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE NEAR HIGH HEAT/OPEN
FLAME. AVOID PRLNGD/FREQUENT RPTD SKIN CNTCT W/THIS MATL. SKIN
CNTCT MAY BE MINIMIZED BY WEARING IMPERVIOUS GLOVES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NOT APPLICABLE FOR INTENDED USE. HOWEVER, IF
UNUSUAL OPERATING CONDITIONS CREATE CONCENTRATIONS IN EXCESS OF THE
TLV, A NIOSH/MSHA APPROVED RESPIRATOR IS RECOMMENDED.
Ventilation:NONE NEEDED FOR INTENDED USE. SPECIAL VENT IS NEC ONLY IF
UNUSUAL OPERATING CONDITIONS CREATE CONC IN EXCESS OF TLV.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:CHEM WORK GOGG/FULL LENGTH FSHLD .
Other Protective Equipment:NONE NORMALLY NECESSARY FOR INTENDED USE.
Work Hygienic Practices:AS W/ALL PROD OF THIS NATURE, GOOD PERSONAL
HYGIENE IS ESSENTIAL. HANDS & OTHER EXPOSED AREAS SHOULD BE WASHED
(ING 3)
Supplemental Safety and Health
EFTS OF OVEREXP: SKIN CNTCT W/USED MOTOR OIL IS NOT EXPECTED TO HAVE
SERIOUS EFTS IN HUMANS IF THE OIL IS THORO REMOVED BY WASHING
W/SOAP & H2O. IT IS BELIEVED THAT DURING INTERNAL COMBUST ENGINES
CON TAM OF OIL W/LOW LEVELS OF CANCER CAUSING COMBUST PROD
(POLYNUCLEAR AROMATIC) OCCURS.

HCC:V6
Spec Gravity:0.87 (H2O=1)
Solubility in Water:NIL
Appearance and Odor:DARK LIQUID (THICKNESS DEPENDENT ON VISCOSITY).
SLIGHT HYDROCARBON ODOR.
Percent Volatiles by Volume:NIL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES AND OPEN FLAME.
Hazardous Decomposition Products:CO2, H2O VAPOR. MAY PRODUCE SOX, NOX &
POX. INCOMPLETE COMBUSTION CAN PRODUCE CO.

Waste Disposal Methods:PLACE CONTAMINATED MATERIAL IN DISPOSABLE
CONTAINERS AND BURY IN AN APPROVED LANDFILL SITE PER LOCAL, STATE
AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.